Science and Engineering

News

15 June 2018

Waste oil from orange, tea tree and eucalyptus essential oil production mixed with diesel provides a sweet-smelling biofuel blend with comparable performance to diesel-only fuel.

QUT PhD researcher Ashrafur Rahman tested each of the waste oils for performance and emissions as a 10 per cent oil/90per cent diesel blend in a 6-cylinder, 5.9l diesel engine.

“As only therapeutic grade oil can be used, there is a substantial volume of low-value waste oil that currently is stored, awaiting a use,” Mr Rahman said.

“Our tests found essential oil blends produced almost the same power as neat diesel with a slight increase in fuel consumption.

“Diesel particulate emissions, which are dangerous to human health, were lower than pure diesel, but nitrogen oxide emissions, a precursor to photochemical smog, were slightly higher.”

Mr Rahman said the abundance of the three oils could mean that fragrant fumes on farms were not far off.

“Orange, eucalyptus and tea tree are either native or grown extensively in Australia for essential oil production.

“We see the main use for an essential oil/diesel blend would be in the agricultural sector, especially in the vehicles used by the producers of these oils.

“With further improvement of some key properties, essential oils could be used in all diesel vehicles.”

Mr Rahman conducted his research in QUT’s Biofuel Engine Research Facility. Property tests of the oils were also carried out by Colorado State University, Southern Cross University and the University of the Sunshine Coast.

The report, Performance and combustion characteristics analysis of multi-cylinder CI engine using essential oil blends, was published in the journal, Energies and in QUT eprints.

Mr Rahman is grateful to Australian Botanical Products (ABP), G.R. Davis Pty Ltd, Australian Tea Tree Oil Exchange (ATTOX) and Main Camp Natural Extracts (MCNE) for sourcing the essential oils. We also acknowledge Ashley Dowell, secretary of the Essential Oil Producers Association of Australia and researcher at Southern Cross University, for his continuous help throughout the study.

QUT Media contact:

Niki Widdowson, 07 3138 2999 or n.widdowson@qut.edu.au

After hours: Rose Trapnell, 0407 585 901

 

 

Contacts

General enquiries and student services

  • Twitter
  • LinkedIn
  • Facebook
  • Instagram
  • Level 3, O Podium
    Gardens Point
    2 George St
    Brisbane QLD
  • Postal address:
    QUT Science and Engineering Faculty
    GPO Box 2434
    Brisbane QLD 4001